Komatsutruckselectric (445e / 510e / 630e / 685e)
Komatsu AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED)
Maintenance schedule, common problems & OEM parts breakdown
The Komatsu AFE44-A (510E) is a rigid-frame, diesel-electric mining haul truck in the roughly 136 t (300,000 lb) payload class, built around a mechanically governed Detroit Diesel 12V-149TIB turbocharged/intercooled two-stroke V12 rated near 1,350 hp gross (about 1,279 hp net) at 1,900 rpm. The engine drives a traction alternator that feeds independent rear wheel motors, eliminating a torque converter and conventional final drives. The "510" designation reflects a nominal gross vehicle weight near 510,000 lb rather than payload. Komatsu inherited this truck through the 1988 Komatsu-Dresser joint venture as the direct successor to the mechanical-drive Dresser Haulpak 140DM, carrying forward the diesel-electric Haulpak lineage that Komatsu later extended into its 630E/730E/830E families. This AFE44-A serial run (S/N 31682-3, 31697-9, 31712-8, 31724-5, 31734-5) sits in the early low-31000s production block and was supplied to the Coal & Allied mining operation, running on 33.00R51 tires shared across several contemporary large-frame mining trucks.
Across the 510E's production life the core diesel-electric architecture and 12V-149TIB powertrain stayed consistent, with running changes concentrated in wheel motor cooling, suspension strut design, and electrical/ground-fault protection rather than a clean-sheet redesign. Because the engine is mechanically governed with no electronic control module, there is no digital fault-code history to trace on these units; service records rely on analog gauge readings, oil/gear-oil sampling, and physical inspection. The 510E and its 140DM predecessor are now firmly legacy, out-of-production trucks, and Komatsu's line has since moved on to larger, electronically controlled AC-drive trucks. That makes surviving 510E/AFE44-A units and their Coal & Allied-run examples specifically relevant to the parts and rebuild market: buyers source good used or remanufactured wheel motors, traction alternators, 149-series engine components, and strut/suspension assemblies to keep older fleets running, since new-production OEM support for this generation is limited and rebuild economics increasingly drive replace-versus-repair decisions.
Below: full specifications, fluids & capacities, the factory service schedule, common service parts, verified fault codes, what owners discuss, attachment guidance, the complete assembly directory, and a serial-number reference. Complete parts lists with full OEM part numbers, exploded diagrams, quantities, and fitment data are available free in Heavy Parts AI.
Komatsu AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED) specifications
Engine
| Engine model | Detroit Diesel 12V-149TIB, V-12 configuration |
| Gross power | 1,350 hp (1,007 kW) at 1,900 rpm |
| Net power | 1,279 hp (954 kW) at 1,900 rpm |
| Displacement | Not documented in available sources for this engine variant |
| Cylinders | 12 (V-12) |
| Emissions tier | Not applicable — mechanical diesel of pre-emissions-tier design, no published emissions certification |
Weights
| Empty (unloaded) weight | Approx. 210,100 lb (95,300 kg) |
| Loaded (gross) weight | Approx. 510,000 lb (231,300 kg) |
| Rated payload | Approx. 299,800 lb (136,000 kg) |
| Ground pressure | Not published in available sources |
Dimensions
| Overall length | Approx. 37.3-37.4 ft (11.4 m) |
| Overall width | Approx. 20.9-21.0 ft (6.4 m) |
| Overall height | Approx. 35.5 ft (10.8 m) |
| Wheelbase | Approx. 16.8-16.9 ft (5.15 m) |
| Ground clearance | Approx. 2.1 ft (0.64 m) |
| Tire size | 33.00-51 |
Performance
| Maximum travel speed | Approx. 33.4 mph (53.8 km/h) |
| Dump angle | 45 degrees |
| Heaped capacity (body, class reference) | Approx. 100.7-100.8 cu yd (77.1 cu m) |
| Gradeability | Not published in available sources |
Service capacities (summary)
| Fuel tank | Approx. 700 gal (2,650 L) |
| Hydraulic system | Approx. 108 gal (409 L) |
| Cooling system | Approx. 60 gal (227 L) |
| Engine oil | Not documented in available sources |
Values vary by configuration, region, and serial range — confirm against your machine before planning transport or lifts.
AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED) fluids & capacities
| System | Capacity | Recommended fluid |
|---|---|---|
| Engine crankcase (with filter) | Not documented for this exact serial range in available sources — verify against the OMM lubrication chart or dealer for this unit. | Diesel engine oil per the Komatsu genuine-oil (EO) or equivalent API CF-4/CG-4 class oil grade the OMM specifies, viscosity graded by ambient temperature per the OMM chart. Exact Komatsu brand-name spec not confirmed for this serial range. |
| Cooling system | Not documented for this exact serial range in available sources — verify against the OMM. | Ethylene-glycol based coolant with corrosion/scale inhibitor (Komatsu-type supercoolant or equivalent), mixed per OMM ratio for climate. Exact brand name not confirmed for this serial range. |
| Fuel tank | Not documented for this exact serial range in available sources — verify against the OMM or fuel tank data plate. | Diesel fuel meeting the cetane/sulfur spec called out in the OMM (No. 2-D diesel typical for this era of mechanically-injected two-stroke diesel power). |
| Transmission / powertrain compartment | Not documented for this exact serial range in available sources — verify against the OMM. | Power train (transmission) oil per Komatsu TO or equivalent class specified in the OMM, viscosity graded by climate. |
| Final drives (each side) | Not documented for this exact serial range in available sources — verify against the OMM. | Gear/final-drive oil per Komatsu axle-oil (AXO) spec or equivalent GL-5 class gear oil called out in the OMM. |
| Hydraulic system (tank + circuit) | Not documented for this exact serial range in available sources — verify against the OMM. | Hydraulic oil per Komatsu HO or equivalent anti-wear hydraulic oil spec, viscosity graded by ambient temperature per the OMM chart. |
| Grease points (chassis, pins, bearings) | Not applicable (grease spec only, no fill volume). | Multipurpose lithium-complex EP grease (NLGI grade per OMM climate table) at all pin, linkage, and bearing grease points. |
Capacities are refill values from factory literature — always fill to the dipstick/sight gauge, not the number.
Komatsu AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED) maintenance schedule
| Service interval | Tasks |
|---|---|
| Every 50 h |
|
| Every 250 h |
|
| Every 500 h |
|
| Every 1,000 h |
|
| Every 2,000 h |
|
| Every 6,000 h |
|
| Every 12,000 h |
|
Servicing the AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED) beyond the schedule
Predictive Maintenance & Fluid Analysis
Run scheduled oil, coolant, and wheel-motor gear-oil sampling to catch two-stroke blow-by, blower wear, and gear contamination before failure, since the 12V-149TIB carries no electronic diagnostics to flag trends. Track insulation resistance (megger readings) on the traction alternator and wheel motors at each interval to catch ground faults early. Trend tire and strut pressures against load cycles; on this diesel-electric drivetrain, fluid and electrical trending substitute for the fault-code history a modern ECM-equipped truck would provide.
Corrective & Common Repairs
Expect recurring work on wheel motor brushes and commutators, blower drive components, and fuel injector spray pattern on the mechanically governed 12V-149TIB. Ground faults and insulation breakdown in the traction alternator and wheel motor wiring are common failure points on diesel-electric drive trucks of this age. Front suspension struts and rear suspension cylinders on this frame class see frequent seal and charge-pressure repairs given the sustained haul-road loading typical of a Coal & Allied-type operation.
Overhaul & Rebuild Points
Major overhaul centers on the 12V-149TIB long block: wet cylinder liners, pistons, blower, and turbocharger are the highest-wear items on this two-stroke design and are commonly exchanged as rebuilt units rather than repaired in place. Wheel motors and the traction alternator are rebuilt on condition using insulation and vibration data. Because this is a legacy, out-of-production platform, sourcing rebuildable cores and used driveline components is often the practical path given limited new-parts support.
Seasonal & Environment Servicing
In cold conditions, pre-lubricate and slow-crank the 12V-149TIB before start and confirm block heaters and battery capacity are adequate for the mechanically governed fuel system. In hot, dusty mine environments typical of Coal & Allied-type operations, service the turbocharger/intercooler and blower screens more frequently and inspect wheel motor cooling blowers for packed dust that raises electrical operating temperatures and accelerates insulation aging.
AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED) common service parts
| Part number | Part | Notes | |
|---|---|---|---|
| VE0047 | Filter, Fuel - Secondary | Fuel system service | Check fitment → |
| VE6714 | Filter, Secondary Fuel | Fuel system service | Check fitment → |
| TL9551 | Hose (Fuel Supply To Primary Filter) | Fuel system service | Check fitment → |
| VE0539 | Element, Air Filter | Air intake service | Check fitment → |
| VE6356 | Element, Lube Oil Filter (Spin-On) | Lubrication service | Check fitment → |
Always confirm against your machine's serial number — cross-check any part in Heavy Parts AI before ordering.
AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED) fault codes & troubleshooting
| Code | Meaning | Likely cause | What to do |
|---|---|---|---|
| Low engine oil pressure (red alarm lamp/buzzer) | Engine lube oil pressure has dropped below the safe threshold | Low oil level, worn oil pump, clogged suction screen, or failed pressure sender/switch | Stop engine immediately, check oil level and for leaks, inspect sender before restart |
| High engine coolant temperature (red alarm lamp/buzzer) | Jacket water temperature has exceeded the safe operating limit | Low coolant, blocked radiator core, fan drive fault, or failed thermostat | Reduce load, idle down, check coolant level and radiator airflow, do not shut down hot engine abruptly |
| Low air pressure (brake system) warning lamp/buzzer | Service/park brake air system pressure below safe minimum | Compressor fault, air leak, or restricted line | Stop truck safely, do not move truck until air pressure recovers, inspect compressor and lines |
| Traction/ground fault indicator (drive control cabinet) | Ground fault relay in the diesel-electric drive system has tripped, indicating an insulation fault in the traction wiring, alternator, or wheel motors | Moisture ingress, damaged high-voltage cable insulation, or motor/alternator winding fault | Do not operate; have electrical technician isolate and megger the traction circuit before restart |
| Wheel motor over-temperature warning lamp | A traction (wheel) motor has exceeded its safe winding temperature | Prolonged high-torque operation, blocked motor cooling airflow, or retarding overuse | Reduce speed/load, allow motor to cool, check motor blower operation |
Codes and remedies are general guidance for this model family — always confirm with diagnostic tooling and your dealer before major repairs.
AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED) attachments & work tools
Dump body / carrying body
Factory rear-dump body rated for roughly 136 t (300,000 lb) payload, with struck capacity near 54 m3 (70.7 cu yd) and heaped capacity near 77 m3 (100.8 cu yd). Body dumps at about 45 degrees, with a raise time near 22 seconds and power-down lower time near 13 seconds. No published coal-specific or high-volume body variant is documented for this exact serial range, though mine operators in coal service commonly spec lighter or higher-volume bodies for this truck class.
Tires / wheel equipment
Standard fitment is the 33.00-51 (33.00R51) size, the same size used across the class-comparable Komatsu 630E/730E/830E and similar large rigid-frame haul trucks. Both radial and bias-ply carcasses exist in this size across the industry; no factory-specific tire brand or construction is documented for this serial range.
Engine / power arrangement
Powered by a Detroit Diesel 12V-149TIB, a turbocharged and aftercooled two-stroke V12, rated near 1,350 hp (1,007 kW) gross at 1,900 rpm. This is the Dresser Haulpak-lineage powertrain carried over from before Komatsu's acquisition of the line; no ADEM/ECM electronic engine management is documented for this generation.
Drive system
Diesel-electric drive typical of the Dresser Haulpak 500-series lineage this truck descends from (140DM predecessor), with the diesel engine driving a traction alternator that feeds electric wheel motors at the rear axle. Specific alternator/motor supplier is not confirmed in available documentation for this serial range.
Guarding / protection options
Rock ejectors ahead of the rear tires, canopy or mesh screening over the operator cab, and ROPS-rated cab structure are standard practice across this haul-truck class. No model-specific optional guarding package list is published for the AFE44-A/510E; verify exact fitment with a dealer for this serial range.
All AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED) assemblies by section
Every catalogued assembly group for the Komatsu AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED). Open an assembly to preview the parts inside — full OEM part numbers are available in Heavy Parts AI.
Air System
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Air System : Air Compressor Assembly (Ve1055)
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 6 |
| C***2 | Capscrew - 3/8" - 16nc X 2 3/4" | 6 |
| R***8 | Plug, Pipe | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Air System : Air Compressor Piping & Instl
| CD***19 | Clamp, Worm Drive (1) (Qty 1) (2) | 2 |
| C***1 | Capscrew - 1/2" - 13nc X 3/4" (4) | 2 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Air System : Crankcase & Shaft (Ve1265)
| RK***88 | Note: (1) Included In Rk1388 Unloader Kit | 0 |
| SP***40 | Seat, Unloader Spring | 2 |
| SR***06 | Ring, Back-Up (1) | 1 |
Body Group
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Body Group : Body Pivot Installation
| C***4 | Lockwasher - 1" (1) | 4 |
| EB***37 | Guide, Body | 2 |
| HC***80 | Bushing, Pipe - 1/8" X 1/4" (At Body Pivot Pins) | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Body Group : Body Position Indicator Installation
| DC***79 | Clamp, Indicator Hose | 1 |
| EB***63 | Indicator | 1 |
| TM***93 | Hose, Body Position Indicator | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Body Group : Mud Flap Installation
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 75 |
| C***1 | Nut - 3/8" - 16nc X 2 1/4" | 75 |
| DF***42 | Flatwasher, Plain - 3/4" | 105 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Body Group : Rock Ejector & Fender Installation
| C***8 | Pin, Cotter - 5/16" X 3.00 | 2 |
| EB***60 | Bar, Ejection | 2 |
| EB***59 | Bracket | 2 |
Cab Group
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Air Conditioner & Piping Instl - 2
| CD***05 | Clamp, Worm Drive | 5 |
| DL***34 | Terminal, Ring | 1 |
| HA***00 | Hose | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Air Conditioner Piping & Instl - 1
| 72***15 | Spacer | 1 |
| C***5 | Lockwasher - 7/16" | 4 |
| C***0 | Nut - 1/4" - 20nc (1) - Qty 100 (2) | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Cab Assembly (Pb7937)
| DF***17 | Nut - #10 - 24nc (Brass) | 6 |
| PB***15 | Console Assembly (See Index) | 1 |
| SP***17 | Flat Washer - 1/4" - 20nc | 10 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Cab Assembly - 1 (Pb7937)
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 20 |
| C***4 | Capscrew - 3/8" - 16nc X 1 1/2" (Cab Mounting) (1) | 5 |
| C***7 | Flat Washer - 3/8" (Attaches With #31 Undercab) | 20 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Circuit Breaker Panel
| DF***17 | Nut - #10 - 24nc (Brass) | 4 |
| EB***38 | Bar, Bus | 1 |
| EB***29 | Cover | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Condenser Installation (Fb2830)
| C***3 | Capscrew - 1/2" - 13nc X 11 1/4" (2) | 6 |
| HA***48 | Hose | 1 |
| HA***49 | Hose | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Console Assembly (Pb7515)
| C***1 | Coupling, Pipe (At Left Front Of Anti-Sway Bar) | 4 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 2 |
| DF***91 | Clamp - 2 1/2" | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Door Assembly (Ve6842-R.H./Ve0112-L.H.)
| TD***94 | Capscrew - 5/16" - 18nc X 3/4" | 2 |
| TV***77 | Flat Washer - 5/16" | 2 |
| VS***69 | Hinge - R.H. (Top & Bottom) | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Door Linkage & Sliding Window
| RK***64 | Glass & Channel Kit (Sliding) | 1 |
| RK***65 | Glass & Channel Kit (Fixed) | 1 |
| RK***66 | Kit, Weather Strip | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Driver Seat Installation
| C***5 | Lockwasher - 7/16" | 2 |
| C***0 | Nut, Hex (Grab Handle) | 4 |
| PB***39 | Seat Driver (See Index) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Driver'S Seat Assembly (Pb7839)
| VE***91 | Armrest, Left | 1 |
| VE***51 | Armrest Set | 1 |
| VE***66 | Frame, Backrest | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Driver'S Seat Assembly - 1 (Pb7839)
| VE***77 | Slide, Master | 1 |
| VE***75 | Handle, Backrest | 1 |
| VE***62 | Kit, Slide (1) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Driver'S Seat Assembly - 2 (Pb7839)
| VE***59 | Kit, Air Lumbar Valve | 1 |
| VE***74 | Spring, Backrest Lever | 1 |
| VE***86 | Plate, Tooth | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Driver'S Seat Assembly - 3 (Pb7839)
| VE***89 | Bushing | 8 |
| VE***87 | Snap Ring, Swivel Bottom | 4 |
| VE***65 | Bushing, Slider | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Driver'S Seat Assembly - 4 (Pb7839)
| VE***81 | Kit, Shock Absorber | 1 |
| VE***83 | Axle | 2 |
| VE***62 | Kit, Air Spring | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Heater Assm/A-C Kit (Pb7741-1/Pb4082-2)
| VS***91 | Valve, Expansion (2) | 1 |
| VS***00 | Grommet, Rubber (2) | 1 |
| VS***08 | Switch, Thermostat (2) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Heater Controls
| C***2 | Capscrew - 3/8" - 16nc X 1" (Qty. 10 Not Included In Assm) | 2 |
| C***0 | Nut - 1/4" - 20nc (1) - Qty 100 (2) | 2 |
| CC***07 | Lockwasher - 5/8" (Internal Tooth) | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Heater Piping & Installation
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 2 |
| C***1 | Nut - 3/8" - 16nc X 2 1/4" | 2 |
| C***8 | Lockwasher - 5/16" | 8 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Instrument Panel Installation
| C***1 | Coupling, Pipe (At Left Front Of Anti-Sway Bar) | 1 |
| DC***22 | Drive Screw - #0 X 1/8" (2) | 4 |
| EB***20 | Harness, Light Socket | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Passenger Seat Installation
| 48***57 | Belt, Seat | 1 |
| C***8 | Lockwasher - 5/16" | 4 |
| E***5 | Flat Washer - 3/8" (1)/(2)/(3)/(4) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Windshield Washer Installation
| DC***84 | Lockwasher - 1/4" (Zinc Pl) | 4 |
| PB***14 | Windshield Washer (See Washer Instl, Fig. #40090) | 1 |
| SG***73 | Grommet | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cab Group : Windshield Wiper Installation
| PB***23 | Wiper Blade, Windshield (See Windshield Wiper Pg) | 1 |
| PB***24 | Arm, Wiper (See Windshield Wiper Page) | 1 |
| PB***69 | Motor, Windshield Wiper (See Windshield Wiper Pg) | 1 |
Cooling System
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cooling System : Fan & Fan Drive Installation
| C***0 | Lockwasher, High Collar - 1/2" | 6 |
| EB***55 | Pulley, Fan Drive | 1 |
| PB***42 | Belt, Fan Drive | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cooling System : Fan Guard Installation
| C***2 | Capscrew - 3/8" - 16nc X 1" (Qty. 10 Not Included In Assm) | 6 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 12 |
| C***7 | Flat Washer - 3/8" (Attaches With #31 Undercab) | 18 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cooling System : Radiator Assembly (Pb7939)
| C***6 | Nut - 5/8" - 18nf | 12 |
| C***2 | Capscrew - 3/8" - 16nc X 1" (Qty. 10 Not Included In Assm) | 33 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 85 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cooling System : Radiator Installation
| C***2 | Capscrew - 5/8" - 11nc X 2 1/2" (3) | 4 |
| C***5 | Nut - 5/8" Unc (G5) | 4 |
| C***1 | Lockwasher - 5/8" (3)/(4) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cooling System : Radiator Piping - 1
| C***1 | Plug, Pipe (3) (Qty.1 (4)) | 3 |
| CD***07 | Clamp (Top & Bottom Connections) | 2 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cooling System : Radiator Piping - 2
| C***1 | Plug, Pipe (3) (Qty.1 (4)) | 1 |
| C***0 | Lockwasher, High Collar - 1/2" | 8 |
| C***2 | Capscrew - 1/2" - 13nc X 1.00 | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Cooling System : Radiator Pressurization
| HA***44 | Hose | 1 |
| PB***15 | Regulator, Pressure (See Index) | 1 |
| PB***42 | Vavle, Check | 1 |
Deck Piping Group
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Accumulator (Vd2414)
| RK***37 | Note: (1) Serviced As Part Of Tk0237 Repair Kit | 0 |
| TV***42 | Plug & Poppet Assembly (2) | 1 |
| TV***48 | Nut, Stop (2) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Air Governor Valve Assembly (Vw5504)
| C***0 | Nut - 1/4" - 20nc (1) - Qty 100 (2) | 1 |
| RK***82 | Note: (1) Included In Rk1182 Repair Kit | 0 |
| SH***21 | Plug, Pipe | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Air Tank Drain Valve Assm (Pb4774)
| H***5 | Capscrew - 1/4" - 20nc X 3/4" (Socket Head) | 3 |
| R***4 | Lockwasher - #10 (External Tooth) | 1 |
| R***6 | Reducer, Pipe | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Brake Treadle Valve Assm (Tz6781)
| RK***25 | Kit, Treadle Foot Pedal Mounting | 1 |
| RK***27 | Pilot, Check Kit | 1 |
| RK***28 | Orifice, Check Kit | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Controller Assembly (Ve1249)
| RK***42 | Kit, Seal Check Valve | 2 |
| RK***62 | (2) Included In Rk0262 Hardware Kit | 1 |
| RK***63 | Upper Actuator Plunger & Housing Assembly (2) | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Controller Valve Assembly (Pb6046)
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Differential Manifold Valve Assm (Pb5567)
| RK***23 | Note: (1) Included In Rk0223 Seal Kit | 0 |
| RK***26 | Note: (1) Also Included In Rk0226 Hardware Kit | 0 |
| TL***95 | O-Ring (.006 - 90d) (1) | 6 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Electronic Treadle - Retarding (Pb7326)
| VE***15 | Plate, Base 28 Deg - F | 1 |
| VE***19 | Machine Screw - (3)/(4) | 1 |
| VE***19 | Screw - Round Head | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Hoist Control Valve Assm (Pb1749)
| H***3 | Screw With Lockwashers - #10-32, 3/8" Long | 3 |
| R***1 | Lockwasher - #6 | 2 |
| RK***30 | (2) Included In Rk1130 Major Repair Kit | 0 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Hydraulic Cabinet Assembly
| 12***77 | Plug, Button | 3 |
| C***4 | Lockwasher - 1/4" (1) - Qty 100 (2) | 4 |
| DA***20 | Fitting, Bulkhead - 90 Deg | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Hydraulic Cabinet Assembly - 2
| C***6 | Flat Washer - 1/4" (Plain) | 19 |
| C***7 | Flat Washer - 3/8" (Attaches With #31 Undercab) | 2 |
| C***4 | Lockwasher - 1/4" (1) - Qty 100 (2) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Hydraulic Cabinet Installation
| C***3 | Nut - 1/2" - 13nc (G5) | 4 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 8 |
| C***3 | Capscrew - 3/8" - 16nc X 1-1/4" G5 (1) | 8 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Left Deck Piping - 2 : Unit_01_of_02
| C***9 | Plug, Pipe - 1/4" | 4 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 4 |
| C***9 | Flat Washer - 1/2" (Plain) | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Left Deck Piping - 2 : Unit_02_of_02
| C***9 | Plug, Pipe - 1/4" | 2 |
| C***3 | Nut - 1/2" - 13nc (G5) | 4 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 10 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Left Deck Piping - 3
| EB***79 | Tube | 1 |
| EB***80 | Tube | 1 |
| HA***73 | Hose | 3 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Pedal Base Assembly (Ve3128)
| VE***36 | Shaft, Pivot (Threaded Both Ends) | 1 |
| VE***33 | Pedal Base (Late Models) | 1 |
| VN***41 | Capscrew - 1/4" - 20nc X 1 1/2" (Socket Head) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Solenoid Valve Assembly (Pb5566)
| RK***30 | Note: (1) Included In Rk0230 Seal Kit | 0 |
| SV***12 | O-Ring - .012 (1) | 1 |
| TL***95 | O-Ring (.006 - 90d) (1) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Deck Piping Group : Under Cab Piping
| C***9 | Plug, Pipe - 1/4" | 2 |
| C***0 | Nut - 1/4" - 20nc (1) - Qty 100 (2) | 6 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 2 |
Electric Power Components & Wiring Group
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Blower Inlet Wiring
| CH***42 | Cable (T3) (Alternator To Rectifier-Rd1) | 1 |
| CH***41 | Cable (T2) (Alternator To Rectifier-Rd1) | 1 |
| CH***40 | Cable (T1) (Alternator To Rectifier-Rd1) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Blower Intake Installation
| DC***01 | Lockwasher - #10 - 24nc X 5/8" | 2 |
| EB***53 | Transition | 1 |
| JG***20 | Bar | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Blown Grid Assembly (Eb3442)
| DC***84 | Lockwasher - 1/4" (Zinc Pl) | 54 |
| EB***73 | Grid, Mounting Str | 1 |
| EB***74 | Bus, Bar | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Contactor Box Assembly (Eb3437)
| CH***33 | Cable (7j15) (Blown Grid To Extended Range | 1 |
| CH***34 | Cable (7j17) (Blown Grid To Extended Range | 1 |
| CH***31 | Cable (7j18) (Blown Grid To Extended Range | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Control Cabinet Assembly - 1
| DC***01 | Lockwasher - #10 - 24nc X 5/8" | 2 |
| DC***26 | Screw, Machine - #8 Unc X 3/8" Rd. Hd | 2 |
| DF***17 | Nut - #10 - 24nc (Brass) | 3 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Control Cabinet Assembly - 2
| C***0 | Nut, Hex (Grab Handle) | 2 |
| DC***01 | Lockwasher - #10 - 24nc X 5/8" | 10 |
| DF***17 | Nut - #10 - 24nc (Brass) | 20 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Control Cabinet Assembly - 3
| DC***01 | Lockwasher - #10 - 24nc X 5/8" | 4 |
| DL***41 | Strip, Insulation | 1 |
| DF***17 | Nut - #10 - 24nc (Brass) | 10 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Control Cabinet Installation
| DC***84 | Lockwasher - 1/4" (Zinc Pl) | 1 |
| EB***94 | Cabinet, Control | 1 |
| SP***17 | Flat Washer - 1/4" - 20nc | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Control Cabinet Panel Instl (Eb1004)
| EB***02 | Panel, Term Blk | 1 |
| H***3 | Screw With Lockwashers - #10-32, 3/8" Long | 6 |
| PB***32 | Strip, Terminal | 3 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Control Cabinet Pressure Control
| PB***37 | Hose, Air | 1 |
| TH***98 | Elbow, Rubber | 1 |
| TG***20 | Capscrew - 3/8" - 16nc X 1.00 (G5) (Zinc) | 12 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Control Cabinet Wiring - 1
| DL***50 | Plate, Identification | 1 |
| DC***84 | Lockwasher - 1/4" (Zinc Pl) | 4 |
| EB***09 | Name Plate - Tb21 | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Control Cabinet Wiring - 2
| EB***33 | Control Cabinet, Statex 2 | 1 |
| JG***45 | Cable - 7j3 | 1 |
| PB***85 | Panel, Motor Field Limit | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Control Cabinet Wiring - 3
| DC***84 | Lockwasher - 1/4" (Zinc Pl) | 4 |
| JG***45 | Cable - 7j3 | 1 |
| JG***46 | Cable - 7j7 | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Ddec Wiring Installation
| DC***01 | Lockwasher - #10 - 24nc X 5/8" | 6 |
| DF***17 | Nut - #10 - 24nc (Brass) | 6 |
| EB***87 | Housing | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Electric Power Components Wiring
| CH***38 | Cable (7j1l) (Load Test Box To L.H. Whl Mtr) | 1 |
| CH***33 | Cable (7j15) (Blown Grid To Extended Range | 1 |
| CH***20 | Cable (7j7) (Load Test Box To Blown Grid) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Extended Range Braking
| CH***33 | Cable (7j15) (Blown Grid To Extended Range | 1 |
| CH***46 | Cable (7ga1) (Blown Grid To Rectifier-Rd1) | 1 |
| CH***73 | Cable (7ga1) (Blown Grid To L.H. Whl Motor) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Hydraulic Service Brake Application
| TG***29 | Machine Screw - #10 - 24nc X 1/2" (1) | 6 |
| TB***39 | Housing | 1 |
| TX***32 | Plate, Name (Arr2) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Load Test Box Assembly (Tz8299)
| DC***01 | Lockwasher - #10 - 24nc X 5/8" | 6 |
| PB***50 | Latch & Keeper Set | 1 |
| PB***30 | Post, Center Insulator | 6 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Load Test Box Installation
| CH***38 | Cable (7j1l) (Load Test Box To L.H. Whl Mtr) | 1 |
| CH***16 | Cable (7j7) (Control Cabinet To Blown Grid) | 1 |
| CH***39 | Cable - 7j1r | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Prop/Ddec Box Assembly (Eb4645)
| 42***43 | Clamp, Vinyl - 3/8" I.D. (Inside R.H. Frame Rail) | 1 |
| DD***67 | Machine Screw - #6 - 32nc X 3/4" | 4 |
| DD***68 | Nut - #6 - 32nc | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Rcp Interface Box Assembly (Tz3318)
| 42***43 | Clamp, Vinyl - 3/8" I.D. (Inside R.H. Frame Rail) | 1 |
| DD***67 | Machine Screw - #6 - 32nc X 3/4" | 4 |
| HD***78 | Flat Washer - #8 | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electric Power Components & Wiring Group : Service Light Installation (Fb1533)
| HC***46 | Sleeve, Connector | 1 |
| PB***12 | Lamp Assembly | 2 |
| SP***45 | Bulb, 24v - 15cp (S.C. Bayonet Base) | 2 |
Electrical System
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Auxiliary Jump Start Installation
| EB***48 | Plate, Backer | 1 |
| EB***99 | Bracket, Bent | 1 |
| EB***47 | Gasket, Rubber | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Battery Box - Equalizer Box Instl
| 72***48 | Round | 2 |
| DC***84 | Lockwasher - 1/4" (Zinc Pl) | 12 |
| EB***32 | Cable, Battery | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Battery Equalizer Box Assm (Eb3080)
| DC***01 | Lockwasher - #10 - 24nc X 5/8" | 8 |
| DF***17 | Nut - #10 - 24nc (Brass) | 4 |
| DC***84 | Lockwasher - 1/4" (Zinc Pl) | 15 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Blower Pressure Switch Wiring
| DC***84 | Lockwasher - 1/4" (Zinc Pl) | 4 |
| EB***76 | Cable | 1 |
| PB***73 | Pressure Switch (See Below For Parts) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Drive Axle Housing Light
| 72***62 | Clamp, Vinyl - 5/16" I.D | 2 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 1 |
| C***1 | Nut - 3/8" - 16nc X 2 1/4" | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Electric Starter Installation
| 72***62 | Clamp, Vinyl - 5/16" I.D | 1 |
| C***1 | Lockwasher - 5/8" (3)/(4) | 6 |
| C***9 | Bolt, Hex Head, 5/8"-11, 1 3/4" Long | 6 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Electrical Console Installation
| C***2 | Capscrew - 3/8" - 16nc X 1" (Qty. 10 Not Included In Assm) | 4 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 4 |
| DC***36 | Switch, Starter | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Engine & Ddec Wiring
| 72***62 | Clamp, Vinyl - 5/16" I.D | 1 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 4 |
| DF***42 | Flatwasher, Plain - 3/4" | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Engine Wiring Ddec Installation
| 42***43 | Clamp, Vinyl - 3/8" I.D. (Inside R.H. Frame Rail) | 10 |
| C***1 | Coupling, Pipe (At Left Front Of Anti-Sway Bar) | 1 |
| DC***01 | Lockwasher - #10 - 24nc X 5/8" | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Equalizer Box Wiring Installation
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Ground Level Engine Shutdown
| DC***84 | Lockwasher - 1/4" (Zinc Pl) | 2 |
| EB***13 | Cable - Ladder Light | 1 |
| HE***67 | Machine Screw - #6 - 32nc X 1/2" (2) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Head Light Installation
| AK***27 | Note: (1) Included In Ak1627 Headlight Assm Low Beam 24 V | 2 |
| AK***28 | (2) Included In Ak1628 Headlight Assm - Hi Beam 24 V | 2 |
| DC***04 | Screw, Machine - #12 - 24nc X 1/2" | 12 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Head, Ladder, & Service Light Wiring
| 72***62 | Clamp, Vinyl - 5/16" I.D | 4 |
| AK***22 | Note: (1) Included In Ak1022 Backup Light Assm | 1 |
| AK***27 | (4) Included In Ak1027 Service Light Assm | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : High Mounted Head Light Installation
| AK***27 | Note: (1) Included In Ak1627 Headlight Assm Low Beam 24 V | 2 |
| AK***28 | (2) Included In Ak1628 Headlight Assm - Hi Beam 24 V | 2 |
| C***0 | Nut - 1/4" - 20nc (1) - Qty 100 (2) | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : High Mounted Head Light Installation - 1
| AK***27 | Note: (1) Included In Ak1627 Headlight Assm Low Beam 24 V | 2 |
| AK***28 | (2) Included In Ak1628 Headlight Assm - Hi Beam 24 V | 2 |
| EB***21 | Cable - To High Mounted Headlights | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Hoist & Body Up Warning Switch
| 72***62 | Clamp, Vinyl - 5/16" I.D | 2 |
| DC***01 | Lockwasher - #10 - 24nc X 5/8" | 4 |
| DF***17 | Nut - #10 - 24nc (Brass) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Junction Box & Wiring Installation
| DH***72 | Bushing, Pipe - 1 1/4" X 1" | 1 |
| EB***21 | Cable - To High Mounted Headlights | 1 |
| EB***33 | Junction Box Assm (See Fig 35140) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Junction Box Assembly (Eb1033)
| DC***01 | Lockwasher - #10 - 24nc X 5/8" | 4 |
| DL***41 | Strip, Insulation | 1 |
| DC***84 | Lockwasher - 1/4" (Zinc Pl) | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Left Deck Wiring Installation
| C***1 | Capscrew - 3/8" - 16nc X 16nc X 3/4" | 2 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 2 |
| C***4 | Lockwasher - 1/4" (1) - Qty 100 (2) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Left Deck Wiring Installation - 1
| C***5 | Capscrew - 1/4" - 20nc X 5/8" (1) | 6 |
| C***1 | Capscrew - 3/8" - 16nc X 16nc X 3/4" | 3 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 3 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Left Deck Wiring Installation - 2
| 72***62 | Clamp, Vinyl - 5/16" I.D | 1 |
| EB***12 | Gasket, Edge (Angled) | 1 |
| EB***21 | Cable - To High Mounted Headlights | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Light Assembly
| AK***22 | Note: (1) Included In Ak1022 Backup Light Assm | 3 |
| AK***24 | Light Assembly - Turn/Clearance (See Fig 35395) | 4 |
| AK***26 | (3) Included In Ak1026 Tail & Stop Light Assm | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Light Assembly - 1
| AK***19 | (3) Included In Ak1019 Fog Light Assm - Optional | 1 |
| AK***30 | Bulb - Light - 24v/60w (1)/(2)/(3)/(4) | 1 |
| AK***31 | Flange Assm (1)/(2)/(3)/(4) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Load Weighing Installation (Eb3391)
| 42***43 | Clamp, Vinyl - 3/8" I.D. (Inside R.H. Frame Rail) | 12 |
| 72***62 | Clamp, Vinyl - 5/16" I.D | 3 |
| 78***92 | Sensor, Pressure | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Load Weighing Installation - 1 (Eb3391)
| DF***45 | Flat Washer - 1/4" | 3 |
| EB***76 | Housing - Payload Meter | 1 |
| EB***61 | Bracket, Mounting - Inclinometer | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Load Weighing Installation - 2 (Eb3391)
| 78***27 | Paper, Roll | 10 |
| 78***43 | Control Box Assembly | 1 |
| 78***92 | Sensor, Pressure | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Overspeed Alarm Installation
| PB***51 | Sonalarm, Signal (2) | 1 |
| TX***55 | Harness | 1 |
| VH***17 | Tie, Strap | 5 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Payload Light Assm Eb4086 R.H./Eb4088 L.H.
| DC***01 | Lockwasher - #10 - 24nc X 5/8" | 13 |
| DF***17 | Nut - #10 - 24nc (Brass) | 13 |
| EB***48 | (3) Included In Eb2848 Light Assembly - Red | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Tail Light & Backup Horn Wiring
| AK***22 | Note: (1) Included In Ak1022 Backup Light Assm | 2 |
| AK***24 | Light Assembly - Turn/Clearance (See Fig 35395) | 2 |
| AK***26 | (3) Included In Ak1026 Tail & Stop Light Assm | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Tric Starter, Battery, Equalizer Box Wiring
| EB***32 | Cable, Battery | 1 |
| EB***06 | Harness | 1 |
| EB***63 | Wire | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Electrical System : Turn Signal, Clearance Lights
| 72***62 | Clamp, Vinyl - 5/16" I.D | 2 |
| AK***22 | Note: (1) Included In Ak1022 Backup Light Assm | 1 |
| AK***24 | Light Assembly - Turn/Clearance (See Fig 35395) | 2 |
Engine Group
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Engine Group : Air Cleaner Assembly (Ta3537)
| VS***90 | O-Ring (1) | 3 |
| VS***39 | Body, Lower (Includes Reference #17) | 1 |
| VS***86 | Element, Primary | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Engine Group : Air Cleaner Installation
| C***1 | Coupling, Pipe (At Left Front Of Anti-Sway Bar) | 2 |
| TF***86 | Elbow - 45 Deg | 2 |
| TR***29 | Capscrew - 5/8" - 11nc X 1 3/4" (1) | 26 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Engine Group : Air Cleaner Piping
| C***1 | Coupling, Pipe (At Left Front Of Anti-Sway Bar) | 4 |
| C***1 | Capscrew - 3/8" - 16nc X 2 1/2" (2) | 8 |
| DC***08 | Nipple, Long - 1/8" X 1 1/2" (At Bottom Of Hoist Cylinders | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Engine Group : Air Cleaner Service Indicator Piping
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 12 |
| C***1 | Nut - 3/8" - 16nc X 2 1/4" | 12 |
| TK***63 | Tube, Nylon | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Engine Group : Engine Exhaust Installation
| C***2 | Capscrew - 3/8" - 16nc X 1" (Qty. 10 Not Included In Assm) | 24 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 8 |
| C***4 | Capscrew - 3/8" - 16nc X 1 1/2" (Cab Mounting) (1) | 8 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Engine Group : Engine Gauge Piping
| C***9 | Plug, Pipe - 1/4" | 1 |
| DF***92 | Pipe, Cross | 1 |
| HA***36 | Hose | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Engine Group : Engine Mount & Miscellaneous
| C***5 | Lockwasher - 7/16" | 3 |
| C***1 | Plug, Pipe (3) (Qty.1 (4)) | 6 |
| CD***07 | Clamp (Top & Bottom Connections) | 3 |
Frame Group
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Frame Group : Frame & Decks
| TX***85 | Bumper Extension - R.H | 1 |
| TG***02 | Mount, Rubber | 12 |
| TX***84 | Bumper Extension - L.H | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Frame Group : Handrail Installation
| TW***31 | Chain Assembly | 2 |
| TB***88 | Rod - Formed | 4 |
| VB***33 | Handrail - L.H. - Front | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Frame Group : Hood & Grille Installation
| DA***30 | Hook, Rubber | 2 |
| TY***54 | Lockwasher - 1/2" | 4 |
| TR***43 | Nut - 1/2" - 13nc (1)/(2) | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Frame Group : Ladder, Steps & Bumper Installation
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 4 |
| EB***52 | Step - L.H | 1 |
| H***4 | Capscrew - 3/8" - 16nc X 1/2" (Bracket Mounting) (2) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Frame Group : Mirror Installation
| AK***12 | Mirror, Convex (See Fig 30460) | 2 |
| C***5 | Capscrew - 3/8" - 16nc X 1 3/4" (L.H. Side) | 8 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 16 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Frame Group : Roll Over Protection Installation
| EB***66 | Rops Structure | 1 |
| VN***32 | Capscrew - 1 1/4" - 7nc X 3 3/4" | 24 |
| WA***66 | Flat Washer - 1-1/4" (Hardened) | 24 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Frame Group : Safety Walk Installation
| EB***77 | Strip, Anti-Skid | 1 |
| EB***76 | Strip, Anti-Skid | 1 |
| TM***06 | Strip, Anti-Skid | 1 |
Front Wheel & Brake Group
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Front Wheel & Brake Group : Front Brake Piping
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 9 |
| C***1 | Nut - 3/8" - 16nc X 2 1/4" | 9 |
| EB***77 | Tube | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Front Wheel & Brake Group : Front Disc Brake Assembly (Pb7362)
| TX***04 | Disc, Brake | 1 |
| VS***65 | Lining, End Plate - R.H. (2)/(3)/(4) | 2 |
| VS***63 | (Not Used This Application) | 6 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Front Wheel & Brake Group : Front Spindle, Hub & Brake Instl
| 72***62 | Clamp, Vinyl - 5/16" I.D | 1 |
| 72***18 | Fitting, Relief | 1 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Front Wheel & Brake Group : Front Suspension & Mounting
| C***5 | Capscrew - 3/4" - 10nc X 1 1/2" (For Shipping Only) | 2 |
| C***2 | Capscrew - 3/8" - 16nc X 1" (Qty. 10 Not Included In Assm) | 2 |
| C***2 | Lockwasher - 3/4" (For Shipping Only) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Front Wheel & Brake Group : Front Wheel & Mounting 24 X 51
| AK***27 | Base, Rim - 24 X 51 | 1 |
| AK***44 | Band, Bead Seat - 51" | 1 |
| AK***46 | Lockring - 51" | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Front Wheel & Brake Group : Front Wheel Cover Installation
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 4 |
| C***0 | Lockwasher, High Collar - 1/2" | 8 |
| C***3 | Capscrew - 1/2" - 13nc X 11 1/4" (2) | 8 |
Fuel System
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Fuel System : Fuel System Piping
| C***6 | Capscrew - 3/8" - 16nc X 2" | 4 |
| C***2 | Plug, Pipe - 1" | 2 |
| C***3 | Nut - 1/2" - 13nc (G5) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Fuel System : Fuel Tank Installation/ Quick Fuel - R.H.
| C***3 | Nut - 1/2" - 13nc (G5) | 4 |
| CC***07 | Lockwasher - 5/8" (Internal Tooth) | 4 |
| C***4 | Lockwasher - 1" (1) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Fuel System : Quick Fuel - L.H.
| C***1 | Capscrew - 3/8" - 16nc X 16nc X 3/4" | 2 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 4 |
| C***1 | Capscrew - 3/8" - 16nc X 2 1/2" (2) | 2 |
Hydraulic System
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Air Cylinder Assembly (Pb2569)
| H***9 | Jam Nut - 1/2" - 20nf | 1 |
| RK***01 | Note: (1) Included In Rk2001 Minor Repair Kit | 0 |
| VS***68 | Rod, Piston | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Hoist & Steering Pump Assm (Pb3628)
| CD***09 | O-Ring (1) | 1 |
| RK***78 | Kit, Cartridge | 1 |
| RK***90 | (2) Included In Rk2090 Cartridge Kit | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Hoist & Steering Pump Instl
| C***5 | Lockwasher - 7/16" | 4 |
| C***5 | Nut - 5/8" Unc (G5) | 2 |
| C***2 | Lockwasher - 3/4" (For Shipping Only) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Hoist Control & Piping
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 8 |
| C***4 | Lockwasher - 1/4" (1) - Qty 100 (2) | 6 |
| C***1 | Nut - 3/8" - 16nc X 2 1/4" | 8 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Hoist Cylinder Assembly (Tz5517)
| 72***87 | Poppet, Ball | 2 |
| C***2 | Lockwasher - 3/4" (For Shipping Only) | 18 |
| C***1 | Capscrew - 1/2" - 13nc X 3/4" (4) | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Hoist Cylinder Installation
| C***5 | Capscrew - 3/4" - 10nc X 1 1/2" (For Shipping Only) | 2 |
| C***2 | Lockwasher - 3/4" (For Shipping Only) | 4 |
| JG***93 | Spacer, Bearing | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Hoist Cylinder Piping
| C***5 | Lockwasher - 7/16" | 8 |
| C***9 | Capscrew - 7/16" - 14nc X 1-1/2" | 8 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 26 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Hoist Valve Assembly (Fb1299)
| C***1 | Capscrew - 3/8" - 16nc X 16nc X 3/4" | 4 |
| C***1 | Capscrew - 1/2" - 13nc X 3/4" (4) | 12 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 13 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Hydraulic Filter Assembly (Fb0288)
| DA***41 | Guide | 1 |
| DA***40 | Poppet | 1 |
| FA***38 | Relief Valve Assembly | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Hydraulic Pressure & Return Piping
| C***3 | Nut - 1/2" - 13nc (G5) | 6 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 6 |
| C***0 | Lockwasher, High Collar - 1/2" | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Hydraulic Pump Piping
| C***5 | Lockwasher - 7/16" | 4 |
| C***8 | Plug, Pipe - 1/8" | 1 |
| C***0 | Bolt, Slotted Hex Head - 5/8" - 11, 2" Long | 4 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Hydraulic System Piping
| C***1 | Capscrew - 1/2" - 13nc X 6" | 3 |
| C***3 | Nut - 1/2" - 13nc (G5) | 4 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Hydraulic Tank & Components Instl
| C***9 | Plug, Pipe - 1/4" | 2 |
| C***3 | Pin, Cotter | 2 |
| C***2 | Capscrew - 3/8" - 16nc X 1" (Qty. 10 Not Included In Assm) | 40 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Manifold Valve Assembly (Pb6181)
| PB***93 | Piston Assembly (2) | 1 |
| PB***82 | Manifold | 1 |
| PB***16 | Check Valve Assembly (2) | 3 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Hydraulic System : Unloader Valve Assembly (Pb6491)
| TF***44 | O-Ring - Housing | 1 |
| VE***16 | Washer, Backup (3) | 2 |
| VS***12 | Washer, Backup (2) | 1 |
Options & Miscellaneous
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Options & Miscellaneous : Fast Oil Change
| DA***55 | Hose - Fuel Return | 1 |
| HA***28 | Hose | 1 |
| HA***17 | Hose | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Options & Miscellaneous : Hydrair Charging Kit (Vd4665)
| HC***80 | Bushing, Pipe - 1/8" X 1/4" (At Body Pivot Pins) | 4 |
| PB***08 | Regulator, Nitrogen | 1 |
| SV***30 | Fitting, Straight | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Options & Miscellaneous : International Tool Group (Tm8241)
| DB***54 | Adaptor, Adjusting | 1 |
| FA***29 | Roll-Out Assembly | 1 |
| PB***39 | Coupling, Half (Quick Disconnect - Female) | 3 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Options & Miscellaneous : Lincoln Lube Installation
| 72***62 | Clamp, Vinyl - 5/16" I.D | 9 |
| C***0 | Nut - 1/4" - 20nc (1) - Qty 100 (2) | 4 |
| C***1 | Coupling, Pipe (At Left Front Of Anti-Sway Bar) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Options & Miscellaneous : Lincoln Lube Installation - 1
| C***5 | Capscrew - 3/8" - 16nc X 1 3/4" (L.H. Side) | 4 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 8 |
| C***0 | Plug, Pipe - 3/8" | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Options & Miscellaneous : Lincoln Lube Installation - 2
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Options & Miscellaneous : Service Center - L.H.
| C***2 | Capscrew - 3/8" - 16nc X 1" (Qty. 10 Not Included In Assm) | 16 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 8 |
| C***8 | Lockwasher - 5/16" | 1 |
Rear Wheel & Brake Group
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Rear Wheel & Brake Group : Drive Axle & Mounting
| A***7 | Square, Cut | 1 |
| AK***54 | Locknut - 4.00" - 12nf | 1 |
| C***4 | Plug, Pipe - 1 1/4" | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Rear Wheel & Brake Group : Drive Axle Blower Hose
| C***3 | Capscrew - 3/8" - 16nc X 1-1/4" G5 (1) | 4 |
| HE***11 | Locknut - 3/8" - 16nc (L.H. Side Requires Qty.2) | 4 |
| PB***57 | Hose, Air Axle Blower | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Rear Wheel & Brake Group : Drive Wheel Piping
| C***3 | Nut - 1/2" - 13nc (G5) | 2 |
| CD***07 | Clamp (Top & Bottom Connections) | 16 |
| C***0 | Lockwasher, High Collar - 1/2" | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Rear Wheel & Brake Group : Parking Brake Assembly (Pb7484)
| VE***11 | Spring | 8 |
| VE***33 | Boot (1)/(2)/(3) | 2 |
| VE***14 | Capscrew (1) / (2) | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Rear Wheel & Brake Group : Rear Brake Piping
| C***3 | Nut - 1/2" - 13nc (G5) | 3 |
| C***0 | Plug, Pipe - 3/8" | 8 |
| C***0 | Lockwasher, High Collar - 1/2" | 3 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Rear Wheel & Brake Group : Rear Disc & Parking Brake Instl
| C***2 | Capscrew - 3/8" - 16nc X 1" (Qty. 10 Not Included In Assm) | 2 |
| HA***98 | Hose | 1 |
| HA***99 | Hose, Parking Brake | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Rear Wheel & Brake Group : Rear Disc Brake Assembly (Pb7676)
| AK***71 | Kit, Tubing | 1 |
| SD***82 | Lockwasher - 5/16" (Internal Tooth) | 4 |
| TH***93 | Fitting, Elbow - 90 Deg (3) | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Rear Wheel & Brake Group : Rear Hatch Cover Installation
| C***3 | Pin, Cotter | 2 |
| PB***06 | Latch/Keeper Set (Qty. 1 Back Of Cabinet) | 1 |
| TD***09 | Capscrew - 1/4" - 20nc X 7 1/2" | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Rear Wheel & Brake Group : Rear Lubrication Group
| C***1 | Coupling, Pipe (At Left Front Of Anti-Sway Bar) | 3 |
| CD***05 | Nipple, Long - 1/8" X 1 1/2" (At Bottom Of Hoist Cylinders | 1 |
| DC***08 | Nipple, Long - 1/8" X 1 1/2" (At Bottom Of Hoist Cylinders | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Rear Wheel & Brake Group : Rear Suspension & Mounting
| EB***85 | Retainer, Ball | 1 |
| EB***87 | Rear Suspension Assembly | 1 |
| EB***93 | Housing | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Rear Wheel & Brake Group : Rear Wheel & Mounting
| AK***27 | Base, Rim - 24 X 51 | 2 |
| AK***44 | Band, Bead Seat - 51" | 2 |
| AK***46 | Lockring - 51" | 2 |
Steering System
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Steering System : Steering Accumulator Assembly (Tz0461)
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 2 |
| PB***94 | Charging Valve Assm (1)/(3)/(4) | 1 |
| PB***08 | Bearing - 8" | 2 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Steering System : Steering Accumulator Installation
| 72***62 | Clamp, Vinyl - 5/16" I.D | 3 |
| C***3 | Nut - 1/2" - 13nc (G5) | 36 |
| C***9 | Flat Washer - 1/2" (Plain) | 12 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Steering System : Steering Column & Control Unit Instl
| C***5 | Lockwasher - 7/16" | 2 |
| C***5 | Capscrew - 3/8" - 16nc X 1 3/4" (L.H. Side) | 8 |
| C***3 | Nut - 1/2" - 13nc (G5) | 6 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Steering System : Steering Column Assembly (Pb5765)
| RK***39 | Turn Signal Switch Assembly | 1 |
| RK***71 | (3) Included In Rk0271 Repair Kit | 0 |
| TV***37 | Race, Inner | 1 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Steering System : Steering Control Unit (Pb6995)
| VP***38 | Seal, Dust (3) | 1 |
| VE***16 | Seal, O-Ring (1) | 1 |
| VE***30 | Capscrew | 7 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Steering System : Steering Cylinder & Tie Rod Instl
| AK***57 | Pin, Steering | 6 |
| C***2 | Capscrew - 3/8" - 16nc X 1" (Qty. 10 Not Included In Assm) | 16 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 16 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Steering System : Steering Cylinder Assembly (Fb3123)
| AK***76 | Note: (1) Included In Ak0076 Seal Repair Kit | 0 |
| DA***68 | Ring, Piston (1) | 1 |
| H***4 | Capscrew - 3/8" - 16nc X 1/2" (Bracket Mounting) (2) | 8 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Steering System : Steering Cylinder Piping
| C***2 | Capscrew - 3/8" - 16nc X 1" (Qty. 10 Not Included In Assm) | 3 |
| C***1 | Coupling, Pipe (At Left Front Of Anti-Sway Bar) | 6 |
| C***2 | Lockwasher - 3/8" (Qty. 10 Not Included In Assembly) | 47 |
Komatsu : Afe44-A(510e S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 Coal & Allied) : Steering System : Steering Wheel Assembly
| PB***46 | Button, Horn | 1 |
| PB***99 | Lever, Turn Signal | 1 |
| PB***53 | Plug, Button | 1 |
AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED) serial number reference
On these Komatsu/Dresser-Haulpak mining trucks the PIN/serial plate is riveted to the front frame structure or mounted inside the cab near the operator's seat post or door pillar; on older Haulpak-lineage units it can also be tagged directly on the frame rail below the cab. The plate lists the full factory model/configuration code (e.g. AFE44-A) followed by the individual unit serial number. The AFE-code is an internal engineering/fleet-order configuration code tied to one specific truck model line (AFE44 ties to the 510E), and the trailing letter (A, H, etc.) identifies the specific customer fleet-order batch built to that configuration, each batch carrying its own serial-number run. Read the letter suffix alongside the stamped serial number to confirm which build and fleet a given unit belongs to.
| Prefix | Identifies | Notes |
|---|---|---|
| AFE44-A | 510E rigid-frame mining haul truck, factory configuration/fleet-order code for Coal & Allied | Ties directly to this batch's serial run: S/N 31682-3, 31697-9, 31712-8, 31724-5, 31734-5, built for the Coal & Allied fleet. Successor designation to the Dresser/Wabco Haulpak 140DM chassis line. Powered by a V12 turbocharged, intercooled diesel (149-series family, 12V-149TIB) rated roughly 1007 kW (1350 hp) gross / 954 kW (1279 hp) net at 1900 rpm. Rated payload is about 136,000 kg (300,000 lb); loaded (gross) weight runs close to 231,000 kg (510,000 lb), which is the basis for the 510E model name. The same 510E base model was also built under a separate AFE44-H configuration code for a different customer fleet (Russia, Almazy); that is a different serial run outside this batch, confirm with dealer if cross-referencing it. |
Frequently asked questions
What engine powers the Komatsu AFE44-A (510E)?
A Detroit Diesel 12V-149TIB, a turbocharged and intercooled two-stroke V12 diesel, mechanically governed with no electronic control module, rated at roughly 1,350 hp gross (about 1,279 hp net) at 1,900 rpm.
What is the operating weight of the Komatsu AFE44-A (510E)?
Gross vehicle weight is nominally around 510,000 lb (the source of the "510" designation), with a rated payload capacity of roughly 136 t (300,000 lb).
What replaced the Komatsu AFE44-A (510E)?
The 510E itself was Komatsu's diesel-electric successor to the mechanical-drive Dresser Haulpak 140DM, inherited through the 1988 Komatsu-Dresser joint venture; Komatsu's later large-frame haul trucks such as the 630E/730E/830E families carried the diesel-electric Haulpak lineage forward as the platform aged out of production.
What AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED) owners discuss
What do owners say about the 12V-149TIB two-stroke engine in daily mining duty?
Consensus is that it is a tough, mechanically simple engine with no ECM to fight, but it punishes deferred maintenance. Continuous full-load lugging on haul grades accelerates exhaust valve and liner wear, and the Roots-type blower seals are a known wear point that shows up as rising crankcase pressure and oil carryover if inspection intervals slip. Unit injector calibration and timing are mechanical and require a tech who still knows the two-stroke Detroit procedures, since indicator-height and timing checks are unforgiving of guesswork. Regular oil sampling is treated as mandatory rather than optional on these engines given how quickly blower and ring wear can escalate between services.
How does the DC electric drive typically age on this truck?
Because the drive uses brushed traction motors rather than an AC/inverter system, brush and commutator condition is a recurring inspection item, with commutator resurfacing needed periodically at higher hours. Grid box (retarding resistor) cooling blowers are a common failure point, and a weak blower shows up as a power derate or overtemperature warning under sustained retarding on long grades. Ground fault relays are also known to trip on moisture or dust ingress into high-voltage cabling and junction boxes, which operators say is more often a wiring/insulation issue than an actual motor fault, but each trip should be traced to ground rather than reset and ignored.
What wear patterns are typical for the tires and suspension on a truck this size?
On 33.00R51 tires, heat buildup from haul-road speed and rock cuts/chunking are the two most cited wear drivers, and operators note that tire life is heavily dependent on haul road maintenance rather than the tire itself. Front and rear suspension struts are prone to slow nitrogen/oil leakdown, which shows up as a soft or leaning corner and uneven tire wear if not corrected. At higher hours, frame cracking near the suspension mounts and hoist cylinder pivots is a known fatigue point on this class of rigid-frame hauler and warrants periodic structural inspection. Because this affects frame integrity, have your dealer or a qualified structural inspector verify any suspected cracking before returning the truck to service.
What electrical or sensor issues come up most often?
Wiring harness chafing and insulation breakdown in the engine compartment and near the traction alternator are commonly reported, driven by heat and vibration over the life of the truck. Ground fault detection is sensitive by design, and nuisance trips are usually traced back to compromised harness insulation or moisture in connectors rather than a genuine motor or cable fault. Speed/tachometer sensor drift is also mentioned as a source of erratic propel or retard response. Because ground fault and propel control faults are safety related, have your dealer verify the fault source before clearing codes and returning the truck to duty.
Since this model is out of production, what do owners say about sourcing parts?
Engine-side parts for the Detroit Diesel 149 series remain reasonably available through the aftermarket and specialist diesel shops, since the platform was used across many other applications. Electric-drive components are the harder side of the equation: GE-style traction motors, alternator field parts, and SCR/control modules are increasingly sourced as rebuilt or used cores rather than new stock, and lead times can be long. Operators of this era of truck generally budget for rebuild-exchange programs on the drive system rather than expecting new-in-box replacements.
What should a buyer check before purchasing a used truck from this era and serial range?
Start with engine hours since new or since last major overhaul and recent oil analysis trends, since rising wear metals or fuel dilution point to blower or injector issues. Ask for insulation resistance (megger) test history on the traction alternator and wheel motors, since this is the standard way owners track winding health on a DC drive. Inspect the frame at suspension mounts and hoist cylinder pivots for cracking or prior weld repairs, check suspension struts for leakdown and even ride height, and confirm hoist cylinder and hydraulic system condition under load. Review brake system service records and confirm current tire condition against remaining tread and any heat or cut damage. Because structural, drive, and brake condition are safety and cost drivers on a truck this size, have your dealer or an independent inspector verify all of the above before finalizing purchase.
Compiled from owner and technician discussions across the industry — experiences vary by serial range and machine history.
Need a specific AFE44-A(510E S/N 31682-3; 31697-9; 31712-8; 31724-5; 31734-5 COAL & ALLIED) part?
Search live OEM part data, check fitment, and cross-reference alternatives with Heavy Parts AI.